Rapid reductive catalytic fractionation for holistic valorization of lignocellulose through precise acid tuning and temporal window identification

Reductive catalytic fractionation (RCF) is an effective technique that enables lignin depolymerization into aromatic monomers while preserving cellulose for downstream valorization. However, the typically prolonged reaction durations (>3 h) required for conventional RCF, stemming from slow kinetics of lignin extraction and depolymerization, impeding its industrial scalability. This study systematically investigated solvent composition, acid concentration, and reaction parameters to accelerate RCF kinetics and modulate monomer distribution. Through rapid benchmark reactions measured immediately at target temperature (0 h) using Ni/C, we demonstrated that a phosphoric acid-assisted RCF process in ethanol–water solvent achieves efficient lignin depolymerization. Remarkably, by finely tuning the acid concentration in the reaction system, this approach achieved a high monomer yield of 31% at 0 h, with a remarkably high production efficiency of 3.44 mg monomers per g lignin per min, exceeding most previously reported rates. Time course analysis further established that precise acid tuning and identifying the optimal temporal window are critical for maximizing monomer yield while preserving carbohydrates. Under optimized conditions employing 0.3 wt.‰ H3PO4, an aromatic monomer yield of 43% was attained within only 30 minutes. The resulting cellulose-rich solid residue, containing the RCF catalyst, was directly converted to ethylene glycol (35% yield) via an integrated one-pot aqueous-phase hydrolysis-hydrogenolysis process. This simultaneous valorization strategy also facilitated effective catalyst recovery and reuse. Our work establishes an efficient and potentially scalable rapid RCF paradigm, offering a promising route for the holistic utilization of lignocellulosic biomass.

• Publication year

  2025

• Venue

  RSC Advances

• Publication date

  2025-11-06

• Fields of study

  Medicine, Materials Science, Chemistry, Environmental Science

• Identifiers
  DOI 10.1039/d5ra06710cPMID 41229955PMCID 12603903
• External record

  Open on Semantic Scholar

• Source metadata

  Semantic Scholar, PubMed

• No claims are published for this paper.

• No concepts are published for this paper.

• Integrated process for lignin depolymerization and nanoparticle production using deep eutectic solvent

  2025cited by this paper
• Reductive Catalytic Fractionation of Lignocellulose Toward Propyl- or Propenyl-Substituted Monomers and Mechanistic Understanding.

  2025cited by this paper
• Enhancing monolignol ferulate conjugate levels in poplar lignin via OsFMT1

  2024cited by this paper
• Toward a hydrogen-free reductive catalytic fractionation of wheat straw biomass.

  2023cited by this paper
• Low-temperature degradation of lignin in aprotic solvent system for preparation of monophenolic platform chemicals

  2023cited by this paper
• Theoretical and experimental study of 5-ethoxymethylfurfural and ethyl levulinate production from cellulose

  2023cited by this paper
• Reductive Catalytic Fractionation of Lignocellulosic Biomass: Unveiling of the Reaction Mechanism

  2022cited by this paper
• Multi-pass flow-through reductive catalytic fractionation

  2022cited by this paper
• Optimal sugar release from macroalgal feedstock with dilute acid pretreatment and enzymatic hydrolysis

  2021cited by this paper
• Solvent Effects on Catalytic Reactions and Related Phenomena at Liquid-Solid Interfaces

  2021cited by this paper
• Staged biorefinery of Moso bamboo by integrating polysaccharide hydrolysis and lignin reductive catalytic fractionation (RCF) for the sequential production of sugars and aromatics

  2021cited by this paper
• Acid-catalyzed fractionation of almond shells in γ-valerolactone/water

  2021cited by this paper
• Techno-economic analysis and life cycle assessment of a biorefinery utilizing reductive catalytic fractionation

  2021cited by this paper
• Acid-Catalyzed α-O-4 Aryl-Ether Cleavage Mechanisms in (Aqueous) γ-Valerolactone: Catalytic Depolymerization Reactions of Lignin Model Compound During Organosolv Pretreatment

  2020cited by this paper
• Selective (ligno) cellulose hydrogenolysis to ethylene glycol and propyl monophenolics over Ni–W@C catalysts

  2020cited by this paper
• A sustainable wood biorefinery for low–carbon footprint chemicals production

  2020cited by this paper
• Structural Variations of Lignin Macromolecules from Early Growth Stages of Poplar Cell Walls

  2019cited by this paper
• Task-Specific Catalyst Development for Lignin-First Biorefinery toward Hemicellulose Retention or Feedstock Extension.

  2019cited by this paper
• Fragmentation of Woody Lignocellulose into Primary Monolignols and Their Derivatives

  2019cited by this paper
• Homolytic and Heterolytic Cleavage of β-Ether Linkages in Hardwood Lignin by Steam Explosion.

  2019cited by this paper
• Activation of lignin by selective oxidation: An emerging strategy for boosting lignin depolymerization to aromatics.

  2019cited by this paper
• Catalytic Strategies Towards Lignin-Derived Chemicals

  2018cited by this paper
• Selectivity Control for Cellulose to Diols: Dancing on Eggs

  2017cited by this paper
• The synthesis and analysis of lignin-bound Hibbert ketone structures in technical lignins.

  2016cited by this paper
• Formaldehyde stabilization facilitates lignin monomer production during biomass depolymerization

  2016cited by this paper
• Synergetic Effects of Alcohol/Water Mixing on the Catalytic Reductive Fractionation of Poplar Wood

  2016cited by this paper
• Reductive Catalytic Fractionation of Corn Stover Lignin

  2016cited by this paper
• Total Utilization of Miscanthus Biomass, Lignin and Carbohydrates, Using Earth Abundant Nickel Catalyst

  2016cited by this paper
• Influence of Acidic (H3PO4) and Alkaline (NaOH) Additives on the Catalytic Reductive Fractionation of Lignocellulose

  2016cited by this paper
• Typical conversion of lignocellulosic biomass into reducing sugars using dilute acid hydrolysis and alkaline pretreatment

  2016cited by this paper
• Metal Triflates for the Production of Aromatics from Lignin.

  2016cited by this paper
• Renewable Feedstocks: The Problem of Catalyst Deactivation and its Mitigation.

  2015cited by this paper
• Chemocatalytic hydrolysis of cellulose into glucose over solid acid catalysts

  2015cited by this paper
• Aqueous-phase hydrogenolysis of glucose to value-added chemicals and biofuels: A comparative study of active metals

  2015cited by this paper
• Aromatic monomers by in situ conversion of reactive intermediates in the acid-catalyzed depolymerization of lignin.

  2015cited by this paper
• Nonenzymatic Sugar Production from Biomass Using Biomass-Derived γ-Valerolactone

  2014cited by this paper
• Pseudo-lignin formation and its impact on enzymatic hydrolysis.

  2012cited by this paper
• Metal Chlorides in Ionic Liquid Solvents Convert Sugars to 5-Hydroxymethylfurfural

  2007cited by this paper

• No citing papers are available for this paper.