Full-scale production of VFAs from sewage sludge by anaerobic alkaline fermentation to improve biological nutrients removal in domestic wastewater.

A full-scale project of thermal-alkaline pretreatment and alkaline fermentation of sewage sludge was built to produce volatile fatty acids (VFAs) which was then used as external carbon source for improving biological nitrogen and phosphorus removals (BNPR) in wastewater plant. Results showed this project had efficient and stable performances in VFA production, sludge reduce and BNPR. Hydrolysis rate in pretreatment, VFAs yield in fermentation and total VS reduction reached 68.7%, 261.32 mg COD/g VSS and 54.19%, respectively. Moreover, fermentation liquid with VFA presented similar efficiency as acetic acid in enhancing BNPR, obtaining removal efficiencies of nitrogen and phosphorus up to 72.39% and 89.65%, respectively. Finally, the project also presented greater economic advantage than traditional processes, and the net profits for VFAs and biogas productions are 9.12 and 3.71 USD/m3 sludge, respectively. Long-term operation indicated that anaerobic alkaline fermentation for VFAs production is technically and economically feasible for sludge carbon recovery.

• Publication year

  2018

• Venue

  Bioresource Technology

• Publication date

  2018-07-01

• Fields of study

  Medicine, Chemistry, Environmental Science

• Identifiers
  DOI 10.1016/j.biortech.2018.03.105PMID 29625281
• External record

  Open on Semantic Scholar

• Source metadata

  Semantic Scholar, PubMed

• No claims are published for this paper.

• No concepts are published for this paper.

• Rapid generation of volatile fatty acids (VFA) through anaerobic acidification of livestock organic waste at low hydraulic residence time (HRT).

  2017cited by this paper
• Enhanced volatile fatty acids (VFAs) production in a thermophilic fermenter with stepwise pH increase - Investigation on dissolved organic matter transformation and microbial community shift.

  2017cited by this paper
• Value-adding conversion and volume reduction of sewage sludge by anaerobic co-digestion with crude glycerol.

  2017influential reference
• Bio-electrolytic sensor for rapid monitoring of volatile fatty acids in anaerobic digestion process.

  2017cited by this paper
• Enhanced volatile fatty acids production during anaerobic digestion of lignocellulosic biomass via micro-oxygenation.

  2017cited by this paper
• The use of fermentation liquid of wastewater primary sedimentation sludge as supplemental carbon source for denitrification based on enhanced anaerobic fermentation.

  2016influential reference
• Augmentation of protein-derived acetic acid production by heat-alkaline-induced changes in protein structure and conformation.

  2016cited by this paper
• Improving volatile fatty acids production by exploiting the residual substrates in post-fermented sludge: Protease catalysis of refractory protein.

  2016cited by this paper
• Enhanced volatile fatty acid production by a modified biological pretreatment in anaerobic fermentation of waste activated sludge

  2016cited by this paper
• Volatile fatty acids (VFAs) production from swine manure through short-term dry anaerobic digestion and its separation from nitrogen and phosphorus resources in the digestate.

  2016cited by this paper
• Assessment of crude glycerol for Enhanced Biological Phosphorus Removal: Stability and role of long chain fatty acids.

  2015cited by this paper
• Comparison of single-stage and two-phase anaerobic sludge digestion systems - Performance and microbial community dynamics.

  2015influential reference
• Effect of temperature on short chain fatty acids (SCFAs) accumulation and microbiological transformation in sludge alkaline fermentation with Ca(OH)₂ adjustment.

  2014influential reference
• A review of the production and applications of waste-derived volatile fatty acids

  2014influential reference
• VFAs bioproduction from waste activated sludge by coupling pretreatments with Agaricus bisporus substrates conditioning

  2014cited by this paper
• Screening pretreatment methods to enhance thermophilic anaerobic digestion of pulp and paper mill wastewater treatment secondary sludge

  2013cited by this paper
• Trophic link between syntrophic acetogens and homoacetogens during the anaerobic acidogenic fermentation of sewage sludge

  2013cited by this paper
• Influence of microwave pre-treatment on sludge solubilization and pilot scale semi-continuous anaerobic digestion.

  2013cited by this paper
• Effect of heat-alkaline treatment as a pretreatment method on volatile fatty acid production and protein degradation in excess sludge, pure proteins and pure cultures.

  2012cited by this paper
• Hydrogen production and microbial diversity in sewage sludge fermentation preceded by heat and alkaline treatment.

  2012cited by this paper
• High-solid anaerobic digestion of sewage sludge under mesophilic conditions: feasibility study.

  2012cited by this paper
• Acidogenic fermentation of proteinaceous sewage sludge: Effect of pH.

  2012cited by this paper
• Biological wastewater treatment.

  2011cited by this paper
• Pilot-scale waste activated sludge alkaline fermentation, fermentation liquid separation, and application of fermentation liquid to improve biological nutrient removal.

  2011cited by this paper
• Biological sludge reduction and enhanced nutrient removal in a pilot-scale system with 2-step sludge alkaline fermentation and A2O process.

  2011influential reference
• Using sludge fermentation liquid to improve wastewater short-cut nitrification-denitrification and denitrifying phosphorus removal via nitrite.

  2010cited by this paper
• Waste Activated Sludge Alkaline Fermentation Liquid as Carbon Source for Biological Nutrients Removal in Anaerobic Followed by Alternating Aerobic-Anoxic Sequencing Batch Reactors

  2010influential reference
• Recovery of nitrogen and phosphorus from alkaline fermentation liquid of waste activated sludge and application of the fermentation liquid to promote biological municipal wastewater treatment.

  2009influential reference
• Selective inhibition of methanogenesis to enhance ethanol and n-butyrate production through acetate reduction in mixed culture fermentation.

  2009cited by this paper
• The investigation of effect of organic carbon sources addition in anaerobic-aerobic (low dissolved oxygen) sequencing batch reactor for nutrients removal from wastewaters.

  2009cited by this paper
• Principles and potential of the anaerobic digestion of waste-activated sludge

  2008cited by this paper
• Utilization patterns of volatile fatty acids in the denitrification reaction

  2007cited by this paper
• Effect of ultrasonic, thermal and ozone pre-treatments on waste activated sludge solubilisation and anaerobic biodegradability

  2006cited by this paper
• Standard Methods for the examination of water and wastewater

  1999cited by this paper
• COLORIMETRIC METHOD FOR DETER-MINATION OF SUGAR AND RELATED SUBSTANCE

  1956cited by this paper
• Protein measurement with the Folin phenol reagent.

  1951cited by this paper

• Conversion of municipal biowaste into value-added products toward a circular bioeconomy: bridging the gap between laboratory-scale and full-scale implementation

  2026cites this paper
• Continuous Caproate Production from Sludge Fermentation Liquid with Chain Elongation Enrichment in a Long-Term UASB Reactor

  2026cites this paper
• Rapid production of volatile fatty acids (VFAs) through the co-fermentation of mixed vegetable waste liquid

  2026cites this paper
• Waste-Based Volatile Fatty Acids for Fuel and Chemical Production

  2026cites this paper
• Enhanced Acid Production from Cyanobacterial Sludge by Liquid Fermentation Combined with High-Temperature Thermal Hydrolysis: Focus on Source Tracing of Inhibitors

  2026cites this paper
• Utilizing waste-derived carbon source for partial denitrification-anammox process: Wastewater- and sludge-derived organics.

  2025cites this paper
• Valorization of organic wastes to high-value biochemicals: Performance, economic and environmental impact assessment of free nitrous acid, heat, and sonication pretreatment strategies

  2025cites this paper
• Impact of thermal pretreatment on food waste chemical characteristics alteration during anaerobic fermentation with Saccharomyces cerevisiae inoculation: Protein vs carbohydrate

  2025cites this paper
• Combined strategies for promoting short-chain fatty acids production from waste activated sludge in anaerobic fermentation

  2025cites this paper
• A comprehensive review on criticalness and innovative insights to advance the development of sludge co-fermentation towards short chain volatile fatty acids

  2025cites this paper
• Total-solids-controlled microbial response and volatile fatty acids production in sludge and chicken manure co-fermentation.

  2025cites this paper
• A critical review on the effect of different carbon sources on EBPR: Revaluation of performance and applications

  2025cites this paper
• A comprehensive review on nature-inspired redox systems based on humic acids: Bridging microbial electron transfer and high-performance supercapacitors

  2025cites this paper
• Integrating dark fermentation and electrohydrogenesis for enhanced biohydrogen production from food waste

  2025cites this paper
• A technological and economic analysis of vacuum‐assisted fermentation to augment enhanced biological phosphorus removal at full‐scale

  2025cites this paper
• Membrane Technologies for Separating Volatile Fatty Acids Produced Through Arrested Anaerobic Digestion: A Review

  2025cites this paper
• Kinetic Insights into Biohydrogen Production from Food Waste in DF–MEC System: Impact of Heat and Chloramphenicol Pretreated Sludge

  2025cites this paper
• Organic Waste and Wastewater Sludge to Volatile Fatty Acids and Biomethane: A Semi-Continuous Biorefinery Approach

  2025cites this paper
• Maximizing resource valorization: mono- and co-digestion of food and agricultural wastes with insights into microbial community dynamics

  2025influential citation
• Advancing psychrophilic fermentation: strategies for enhancing volatile fatty acid production

  2025cites this paper
• Flow-Electrode capacitive deionization for enhanced selective separation of Ammonia, Phosphorus, and caproate from sewage sludge fermentation: Performance and mechanistic insights.

  2025cites this paper
• Characteristics of volatile fatty acids production and microbial succession under acid fermentation via anaerobic membrane bioreactor treating kitchen waste slurry.

  2025cites this paper
• Evaluating the impact of membrane properties and feed pH on concentration and fractionation of volatile fatty acid using nanofiltration

  2024cites this paper
• New insight into enhanced carbon recovery from anaerobic fermentation of waste activated sludge with cation exchange resin coupled with NaCl pretreatment.

  2024cites this paper
• Tannic Acid Modulation of Substrate Utilization, Microbial Community, and Metabolic Traits in Sludge Anaerobic Fermentation for Volatile Fatty Acid Promotion.

  2024cites this paper
• Assessing the potential of olive mill solid waste as feedstock for methane and volatile fatty acids production via anaerobic bioprocesses.

  2024cites this paper
• Life cycle carbon footprints of alternative sludge pretreatment technologies to recover carbon sources for denitrification

  2024cites this paper
• Enhancing volatile fatty acid production through thermal hydrolysis of food waste with surfactant additives in anaerobic digestion.

  2024cites this paper
• Carbon-ferrous-sulfur mixotrophic denitrification driven by polyferric sulfate (PFS)-conditioned recovered sludge fermentation liquor enhanced nitrogen removal in woolen wastewater

  2024cites this paper
• Electricity production and nutrient recovery from waste activated sludge via microbial fuel cell and subsequent struvite crystallization: Effect of low temperature thermo-alkaline pretreatment.

  2024cites this paper
• SÜRDÜRÜLEBİLİR KENTSEL BİYOATIK YÖNETİMİ

  2024cites this paper
• Biorefinery-oriented pyrolysis and anaerobic fermentation synergies: Leveraging biomass tar for enhanced chemical production from food waste

  2024cites this paper
• Guidelines for efficient nitrogen preservation in sewage sludge-based fertilizers.

  2024cites this paper
• Harnessing the Potential of Sludge Fermentation Liquid to Induce Partial Nitrification

  2024cites this paper
• Cost Reduction in the Process of Biological Denitrification by Choosing Traditional or Alternative Carbon Sources

  2024cites this paper
• Prefeasibility Analysis of Different Anaerobic Digestion Upgrading Pathways Using Organic Kitchen Food Waste as Raw Material

  2024cites this paper
• Perspectives on Electrochemical Valorization of Organic Waste

  2024cites this paper
• Recovery of organic matters by activated sludge from municipal wastewater: Performance and characterization.

  2024cites this paper
• Simultaneous Recovery of Carbon, Nitrogen, and Phosphorous from Waste Activated Sludge: Influence of pH in Anaerobic Fermentation

  2024influential citation
• Environmental and economic life cycle assessment of emerging sludge treatment routes

  2024cites this paper
• Effect of Inoculum Pretreatment and Substrate/Inoculum Ratio on Acidogenic Fermentation of Chemically Enhanced Primary Treatment Sludge

  2024cites this paper
• Enhanced Wastewater Treatment with an AnF-AAO System for Improved Internal Carbon Source Utilization.

  2024cites this paper
• Free nitrous acid-assisted bioresource recovery from anaerobic digestion of organic materials

  2024cites this paper
• Scale-up and economic assessment of volatile fatty acids production from food waste

  2024cites this paper
• Biochar derived from alkali-treated sludge residue regulates anaerobic digestion: Enhancement performance and potential mechanisms.

  2024cites this paper
• Aerobic-anaerobic DHS reactor for enhancing denitrification in municipal wastewater treatment.

  2024cites this paper
• Low-temperature thermal hydrolysis for enhancing sludge anaerobic digestion and antibiotic resistance management: Significance of digester solids retention time.

  2024cites this paper
• Carbon fixation via volatile fatty acids recovery from sewage sludge through electrochemical-pretreatment-based anaerobic digestion.

  2024cites this paper
• Advances in the research on N and O dual isotope analysis of biological nitrogen removal performance

  2024cites this paper
• Chemical characteristics of dissolved organic matter in effluent from sludge alkaline fermentation liquid-fed sequencing batch reactors.

  2024cites this paper
• Biofiltration for low-carbon rural wastewater treatment: a review of advancements and opportunities towards carbon neutrality

  2024cites this paper
• Performance of volatile fatty acids production from food waste at the presence of alkyl ethoxy polyglycosides and sodium dodecyl sulfate.

  2023cites this paper
• Influences of humic acids released during sludge thermal hydrolysis on anaerobic digestion: New insights from enzymatic perspectives

  2023cites this paper
• Hydrothermal Pre- and Inter-Treatment for Anaerobic Digestion of Municipal Sludge

  2023cites this paper
• Oxygen limitation in aerobic polyhydroxyalkanoates production from sewage sludge anaerobic fermentation liquids under low and medium organic loading rate.

  2023cites this paper
• Volatile fatty acids bio-production using extracellular polymeric substances disengaged from sludge for carbon source recycling.

  2023cites this paper
• Creating Value from Acidogenic Biohydrogen Fermentation Effluents: An Innovative Approach for a Circular Bioeconomy That Is Acquired via a Microbial Biorefinery-Based Framework

  2023cites this paper
• Detection of volatile fatty acids in anaerobic digestion system by near infrared spectroscopy

  2023cites this paper
• Separation of nutrients and acetate from sewage sludge fermentation liquid in flow-electrode capacitive deionization system: Competitive mechanisms of ions and influence of activated carbon.

  2023cites this paper
• Machine learning enabled prediction and process optimization of VFA production from riboflavin-mediated sludge fermentation

  2023cites this paper
• Effective mitigation of ammonia in sewage-sludge-derived fermentation liquid using flow-electrode capacitive deionization.

  2023cites this paper
• Contribution identification of hydrolyzed products of potassium ferrate on promoting short-chain fatty acids production from waste activated sludge.

  2023cites this paper
• An efficient strategy for improving short-chain fatty acid production from sludge anaerobic fermentation with calcium carbide residue addition

  2023cites this paper
• Bioproduction and applications of short-chain fatty acids from secondary sludge anaerobic fermentation: A critical review

  2023cites this paper
• How formate dehydrogenase-lacking acetogen Clostridium bovifaecis utilize formate as the sole carbon source for its acetogenic growth?

  2023cites this paper
• Study on sewage characteristics in rural China and pollutants removal performance of biologically enhanced internal circulation treatment system

  2023influential citation
• Thermo-alkaline pretreatment of excess sludge: Effects of temperature on volatile fatty acids accumulation and microbial community.

  2023cites this paper
• Thermophilic Dark Fermentation for Simultaneous Mixed Volatile Fatty Acids and Biohydrogen Production from Food Waste

  2023cites this paper
• Conceptual system for sustainable and next-generation wastewater resource recovery facilities.

  2023cites this paper
• Organics Recovery from Waste Activated Sludge In-situ Driving Efficient Nitrogen Removal from Mature Landfill Leachate: An Innovative Biotechnology with Energy Superiority

  2023cites this paper
• Simultaneous production of biogas and volatile fatty acids through anaerobic digestion using cereal straw as substrate

  2023cites this paper
• Application and improvement methods of sludge alkaline fermentation liquid as a carbon source for biological nutrient removal: A review.

  2023cites this paper
• Feasibility of membrane distillation brine assistant anaerobic fermentation for enhancing carbon migration and recovery from excess sludge: Two wastes into one resource

  2023cites this paper
• Effects of self-produced lactic fermentation (SPLF) on GHG and VSC emissions during swine slurry storage.

  2023cites this paper
• Enhanced short chain fatty acids production from anaerobic fermentation of primary sludge using free ammonia pretreatment

  2023cites this paper
• Understanding acidogenesis towards green hydrogen and volatile fatty acid production – Critical Analysis and Circular Economy Perspective

  2023cites this paper
• Volatile fatty acids production from municipal waste streams and use as a carbon source for denitrification: The journey towards full-scale application and revealing key microbial players

  2023cites this paper
• Mitigation of N2O emissions via enhanced denitrification in a biological landfill leachate treatment using external carbon from fermented sludge.

  2023cites this paper
• Effects of Potassium Ferrate and Low-Temperature Thermal Hydrolysis Co-Pretreatment on the Hydrolysis and Anaerobic Digestion Process of Waste Activated Sludge

  2023cites this paper
• EDTA-enhanced alkaline anaerobic fermentation of landfill leachate-derived waste activated sludge for short-chain fatty acids production: Metals chelation and EPSs destruction.

  2023cites this paper
• Assessment of bioconversion performance after alkaline fermentation process to recover biogas and nutrients

  2022cites this paper
• Two kinds of behavior of fruit peel coagulant in treating low carbon source wastewaters

  2022cites this paper
• Factors influencing pressure-driven membrane-assisted volatile fatty acids recovery and purification-A review.

  2022cites this paper
• Differential impact of acidic and alkaline conditions on hydrothermal pretreatment, fermentation and anaerobic digestion of sludge.

  2022cites this paper
• Microwave-Hydrogen Peroxide Assisted Anaerobic Treatment as an Effective Method for Short-Chain Fatty Acids Production from Tannery Sludge

  2022cites this paper
• Enhanced dewaterability of anaerobically fermented sludge through acid-driven indigenous enzymatic hydrolysis.

  2022cites this paper
• Induced air flotation for fat, oil, and grease recovery in urban wastewater: A proposed methodology for system optimization and case study

  2022cites this paper
• Efficient production of poly-3-hydroxybutyrate from acetate and butyrate by halophilic bacteria Salinivibrio spp. TGB4 and TGB19.

  2022cites this paper
• Waste-derived volatile fatty acid production and ammonium removal from it by ion exchange process with natural zeolite

  2022cites this paper
• Response of anaerobic digestion of waste activated sludge to types of alkalis: Contribution identification of metal ions.

  2022cites this paper
• Re-circulation of Fe/persulfate regulated sludge fermentation products for sewage treatment: Focus on pollutant removal efficiency, microbial community and metabolic activity.

  2022cites this paper
• Sewage sludge treatment technology under the requirement of carbon neutrality: Recent progress and perspectives.

  2022cites this paper
• Coupled process of in-situ sludge fermentation and riboflavin-mediated nitrogen removal for low carbon wastewater treatment.

  2022cites this paper
• Continuous Production of Volatile Fatty Acids (VFAs) from Swine Manure: Determination of Process Conditions, VFAs Composition Distribution and Fermentation Broth Availability Analysis

  2022cites this paper
• Valuable Routes for Sewage Sludge Utilization: Effect of Temperature and Hydraulic Retention Time in the Acidogenic Fermentation Process

  2022cites this paper
• Impact of a Pretreatment Step on the Acidogenic Fermentation of Spent Coffee Grounds

  2022cites this paper
• Oriented bio-feeding control of the anaerobic biodegradation of ethinyl estradiol.

  2022cites this paper
• Application of Primary Sludge Fermentation for the Production of Carbon Source for Full-Scale Biological Nutrients Removal

  2022cites this paper
• Sewage sludge as carbon source for polyhydroxyalkanoates: A holistic approach at pilot scale level

  2022cites this paper
• Production of Docosahexaenoic Acid and Odd-Chain Fatty Acids by Microalgae Schizochytrium limacinum Grown on Waste-Derived Volatile Fatty Acids

  2022cites this paper